Squarebirds, Rocketbirds, and Fifties/Sixties Ford Discussion Forum

Squarebirds, Rocketbirds, and Fifties/Sixties Ford Discussion Forum (http://squarebirds.org/vbulletin/index.php)
-   1961 To 1963 Bulletbirds, Rocketbirds - General Technical Discussion (http://squarebirds.org/vbulletin/forumdisplay.php?f=24)
-   -   62 heater core (http://squarebirds.org/vbulletin/showthread.php?t=20799)

gas62tbird 08-10-2016 09:58 PM

62 heater core
 
Hi I recently replace the heater core in my 62 and put in a exterior heater control valve in the engine compartment and hooked it up the smaller heater hose from top of water pump to lower connection of heater core. Now my question is why am I still getting heat in the interior when inner control is in the off position and I verified the heater control valve is completely closed.
Now bear with me while I explain my confusion in the flow of coolant as shown in the shop manual.Here goes flow the heated coolant flow from the intake[larger hose] to the top connection of heater core through the heater core to exit from bottom connection through the control valve [smaller hose] to the top of the water pump. What's confusing logically you would think the control valve would be connected to top connection of heater core as the hot coolant is flowing into the heater core from intake and if I am to install a shut off valve flow for the summer should it not be in the larger hose that flows to top connection of heater core. Can someone shed some light on this one. Thanks

simplyconnected 08-11-2016 05:24 AM

Flow can only happen when BOTH heater hoses have openings. That also means it doesn't matter which hose you block. No flow in any part of this circuit means no heat to the core.

Try this... Take a pair of vice-grips or a 'C' clamp and squeeze one of the hoses so that flow stops. If the jaws are too small, sandwich two plates to cover the hose. You can do this in any convenient part of the hose with your new valve closed or open. After the engine warms up, feel both hoses as you check for heat.

With the clamp in place, take a test ride and tell us the result. - Dave

gas62tbird 08-11-2016 11:42 AM

heater core
 
Good idea, Thanks Dave will let you know.

gas62tbird 09-03-2016 10:39 AM

Heater Core
 
Sorry For Late Reply Dave But Thanks For Input Your Idea Worked So I Installed A Shut Off Valve For The Summer,

Thanks Again!


All times are GMT -4. The time now is 12:44 AM.

Powered by vBulletin® Version 3.6.8
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Any submissions to this site and any post on this site becomes property of Squarebirds.org . The webmasters reserve the right to edit and modify any submissions to this site. All material on this is site is copyrighted by the Squarebirds.org. Reproduction by any means other than for personal use is strictly prohibited. Permission to use material on this site can be obtained by contacting the webmasters. Copyright 2002-2016 by Squarebirds.org.